Part 2 - 393 Level II Mechanical Exercise

JavaScript isn't enabled in your browser, so this file can't be opened. Enable and reload.

Email *

It is 2:00 pm and you are doing a Level II inspection. You notice a head light out. What would you write it under and is this an OOS?

1 point

Write a 393.9 as a violation and allow to proceed.

Tell the driver about the light and allow to proceed to next stop and fix it.

Write a 393.9 and place the truck OOS.

Write a 393.11 violation and allow to proceed.

Clear selection

While inspecting a truck you ask the driver to pump the brakes until the brake low air warning device comes on. The warning device must begin to activate at no less than ____________ psi.

1 point

60 psi

55 psi

45 psi

90 psi

Clear selection

While inspecting a truck you find the windshield has a single crack from one corner of the windshield to the other corner. Is this a violation?

1 point

Yes

Clear selection

While inspecting a tractor semi-trailer combination you find on the trailer a disc wheel with a single crack, two inches long. Is the semi-trailer out-of-service?

1 point

Yes

Clear selection

Under 393.60 exceptions (2) decals or stickers can not extend more than ___ inches from the bottom of the windshield?

1 point

2 inches

1.5 inches

4.5 inches

None of the above

Clear selection

As you move along in your inspection you see a fuel tank being secured by a cargo strap. What action do you take?

1 point

As long as the straps are tight let the driver proceed.

Write for 393.65(c) and place driver OOS.

Write for 393.65(c) and place truck OOS

Write for 393.65(c) as a violation

Clear selection

Per North American Standard Level II procedure (found in the spiral bound OOS criteria) what step do you test air loss rate?

1 point

Clear selection

At what point would you write 393.45(b)(2) as an OOS?

1 point

Wear makes reinforcement ply visible, but ply is intact

Any part of the fabric/steel braid reinforcement ply is frayed, severed or cut

Wear extends through outer protective material into outer cover

All of the above

Clear selection

Per the safety notice on conspicuity, reflective tape is not required on:

1 point

Pole Trailers

Straight Trucks

Intermodal Containers

All of the above

Clear selection

You are inspecting a trailer for cracks and find one that is longer than an inch in the siderail bottom flange. What do you write it under?

1 point

393.201(a) as a violation

393.201(a) and put OOS

393.209(d) as a violation.

393.209(d) and put OOS

Clear selection

You are doing an inspection on a stinger steered auto hauler at 10 am and his load extends more than 4 feet off the rear with no warning flags. What is the violation?

1 point

393.87(b) and place OOS

None per the Safety notice

393.87(b) as a violation

393.11 (a)(1) and place OOS

Clear selection

You see this combination come into the scale and the safety chains are not attached between the truck and trailer. What violation would you write if any?

1 point

Do an inspection and write for a 393.70(d) and place OOS

Do an inspection and write for 392.2SAFCH and put OOS

Nothing and cite for 818.150 in violation of Oregon Law

Do an inspection and write for 392.2SAFCH as a violation and allow to proceed

Clear selection

A dump truck and pup come into the scale. You decide to do an inspection. As you do your walk around you notice the pintle hook is missing the safety device that keeps the securement latch in the closed position. Is there a violation? If so what would you write it under?

1 point

393.70(d)(1) as a violation

393.71 and put OOS

392.2SAFCH as a violation and allow to proceed

393.70(c)(4) and put OSS

Clear selection

As your are weighing trucks you see this vehicle come through the scale. You park them and do an inspection. What is the violation if any?

1 point

393.9(a) inoperative stop lamps

393.23 all electrical systems on towed vehicle inoperative due to no electrical connection and place OOS.

393.9(a) inoperative turn signals

All of the above

Clear selection

Do you see a violation here? Yes/No _____? If yes what would you write it for?

1 point

No because that is a proper connection

Yes, Write for 393.45(d) audible air leak at other than a proper connection and let driver go

Yes, Write for 393.45(d) improperly joined by tubing and secured with hose clamps and place vehicle OOS.

No, Write for 393.45(d) audible air leak at other than a proper connection and let driver go

Clear selection

Any tire with visually observable bump or knot apparently related to tread or sidewall separation would be written under what violation code?

1 point

393.75(a)(3)

393.75(a)(2)

393.75(a)(1)

393.75(g)(1)

Clear selection

What violation code would you write for an ABS light malfunction?

1 point

393.11

393.9

393.48

393.55

Clear selection

You see 25% or more of the leaves in a spring assembly to be broken. What violation would you write it under and place it OOS?

1 point

393.207 (a)

393.207 (e)

393.207 (c)

393.207 (f)

Clear selection

You are inspecting the low air pressure warning device on a 2002 Peterbuilt. The driver pumps the brakes down and a buzzer comes on before the air pressure reaches 55 psi. However, the light does not come on even after being pumped down below 55 psi. What do you do if anything?

1 point

As long as the buzzer is working there is no violation.

Write a 393.51 violation and place the vehicle OOS.

Write a 393.51 violation because a light is mandatory and the buzzer is secondary.

Advise the driver he should get it fixed.

Clear selection

You stop a CMV straight truck that is less than 80 inches wide. Are clearance light required?

1 point

Yes.

No.

Clear selection

During an inspection you notice the drawbar eye on the full trailer has been repaired by a weld. What do you do if anything?

1 point

No Violation.

Write a 393.70(c) violation and don't place OOS.

Write a 393.70(c) violation and place OOS.

Write a 396.3(a)(1) violation and place OOS.

Clear selection

You stop a CMV hauling a travel trailer from the manufacturer to the dealership (driveaway towaway). During your walk around inspection you discover that the wire for the trailer breakaway system is not directly attached to the vehicle. What do you do if anything.

1 point

Write a 393.43(d) violation and place the vehicle OOS.

Nothing, this vehicle is exempt because it is drive-away-tow-away.

Write a 393.43(d) violation and let the vehicle proceed.

Write a 396.3(a)(1) violation and place vehicle OOS.

Clear selection

A fuel line that is not completely enclosed in a protective housing must not extend more than _____ below the fuel tank or sump?

1 point

6 Inches.

1 foot.

1 inch.

2 inches.

Clear selection

You are inspecting the rear of a trailer and both turn signals do not work, the brake lights do not work the hazard lights do not work and the tail lights do not work. You verify the plug is connected to the trailer. According to CVSA Policy 14 how many violations do you write?

1 point

Clear selection

During an inspection you find a tire that seems flat. Who should you have check the air pressure in the tire?

1 point

To save time I will measure it myself.

Have the driver do it in case something gets broke or the valve stem gets stuck open.

Find the lowest ranked person in your area to do it.

Have the hitchhiker who is unauthorized to ride in the vehicle to do it.

Clear selection

This truck and trailer come through the scale chained up with the tires and wheels missing. What do you do if anything?

1 point

As long as he is not over weight Policy 15 says to let it go.

Write a 396.3(a)(1) violation and place vehicle OOS.

Write two 393.75 violation for tires missing and let him go.

Write 393.75 violation for missing tires and place OOS.

Clear selection

A copy of your responses will be emailed to the address you provided.

Submit

Clear form

reCAPTCHA

Privacy Terms

This content is neither created nor endorsed by Google. Report Abuse - Terms of Service - Privacy Policy

Forms